Prep Table & Sandwich Unit Repair in Piper Glen, Charlotte
Need prep table and sandwich unit repair in Piper Glen, Charlotte? We send commercial technicians to restaurants, bars, stores and institutional kitchens across Piper Glen every week.
- Licensed & insuredCommercial refrigeration and kitchen equipment technicians
- $135 service callClear price before any work starts
- $50 off your repairWhen you book online or mention the website
- Warranty on every job30-day labor, 90-day parts, extended 1, 3 or 5 years on select work
- Open 7 days a weekMon–Sat 8 AM–6 PM · Sun 10 AM–3 PM
- Same-day serviceWhen you call early — trucks stocked with common parts
Sandwich, salad and pizza prep tables are some of the hardest-working refrigeration on the line. Pans on top have to stay at 41°F or below while the lid is open for hours. We repair sandwich/salad units, mega-top units and pizza prep tables.
Prep Table & Sandwich Unit repair for Piper Glen businesses
Piper Glen sits between Ballantyne and Blakeney, close to country clubs and restaurant corridors on Rea Road. We serve businesses near Rea Road, Piper Glen Drive and Carmel Road, including ZIP codes 28277 in Mecklenburg County, NC.
From quick-service counters near Carmel Road to full kitchens near Rea Road, Piper Glen businesses rely on us for prep table and sandwich unit work. If a repair is not worth the money, we tell you and quote the replacement — no Piper Glen customer is pushed into a new unit they don't need. We document every visit with the temperatures we measured and the parts we replaced, which helps Piper Glen managers with inspections and budgeting. Summer heat in the Charlotte region pushes condensers and compressors to their limit; for Piper Glen kitchens we check airflow, coil condition and electrical parts on every visit.
Signs you need prep table and sandwich unit repair
- Top rail pans above 41°F
- Cabinet cold but rail warm
- Water leaking into the cabinet
- Compressor overheating
- Ice on the coil
- Lid hinge broken or lid not closing
What our technicians do
Warm rail pans are the classic complaint. The causes are usually a dirty condenser, a weak evaporator fan, a blocked air duct to the rail, low refrigerant or a failed thermostat.
- Thermostat and controller replacement
- Rail airflow and duct repair
- Leak repair and recharge
- Fan motor replacement
- Condenser cleaning
- Lid hinge and gasket replacement
Save $50 on your repair
Book online or mention our website when you call and we take $50 off the repair. The service call is a flat $135, and you get a clear price before any work begins — no surprises.
Typical jobs we handle
Examples of common repairs on commercial refrigeration and kitchen equipment.
- Prep Table & Sandwich UnitPizzerias
Pizza prep table rail pans at 46°F
- What we found
- Dirty condenser and weak evaporator fan
- What we did
- Cleaned the condenser, replaced the fan motor, rail back to 39°F
✓ Typically fixed in one visit
- Prep Table & Sandwich UnitRestaurants
Sandwich unit lid won't stay open
- What we found
- Broken lid hinge pin
- What we did
- Replaced the hinge set and adjusted the lid
✓ Typically fixed the same day
- Soft Serve & Frozen Drink MachineIce Cream & Frozen Yogurt Shops
Soft serve coming out runny
- What we found
- Dirty condenser and worn drive belt
- What we did
- Cleaned the condenser, replaced the belt, adjusted viscosity
✓ Typically fixed in one visit
- Draft Beer & Keg CoolerBreweries & Taprooms
Foamy pours on every tap
- What we found
- Glycol chiller pump failing, lines warming
- What we did
- Replaced the glycol pump and topped up glycol
✓ Typically fixed in one visit
- Walk-In CoolerBreweries & Taprooms
Keg walk-in short-cycling on hot afternoons
- What we found
- Failed run capacitor and pitted contactor
- What we did
- Replaced capacitor and contactor, tested compressor under load
✓ Typically fixed in one visit
- Commercial FryerConvenience Stores & Gas Stations
Fryer overheating and tripping the high-limit
- What we found
- Temperature probe failing
- What we did
- Replaced the probe and calibrated the controller
✓ Typically fixed in one visit
- Refrigerated Display CaseBakeries
Bakery display case warm at the front
- What we found
- Evaporator iced from a bad defrost timer
- What we did
- Replaced the timer, defrosted, verified temperatures
✓ Typically fixed in one visit
- Mixer, Slicer & Food PrepBakeries
Planetary mixer grinding in second speed
- What we found
- Worn transmission gear
- What we did
- Replaced the gear and lubricated the gearbox
✓ Usually needs a part ordered — two visits
Examples for illustration. Every job is diagnosed on site; parts, time and price depend on the equipment.
Prep Table & Sandwich Unit brands we repair in Piper Glen
Common problems
Who we serve in Piper Glen
Technician tip
Close the rail lid during slow periods — it cuts compressor run time and keeps pans at a safe temperature.
Our warranty
Labor warranty on every repair.
Parts warranty on every part we install.
Extended warranty available on select repairs and installations. The exact term is written on your estimate before work starts.
Frequently asked questions
Why are my prep table pans warm but the cabinet is cold?
The rail depends on airflow from the evaporator. A weak fan, iced coil or blocked duct starves the pans first.
Can a prep table hold food safely overnight in the rail?
Most manufacturers recommend moving pans to the cabinet or a walk-in overnight; rail units are designed for service hours.
How much does prep table and sandwich unit repair cost in Piper Glen, Charlotte?
The service call is a flat $135, which covers the trip and diagnosis. After diagnosis you get a written price for the repair before any work starts, and you save $50 on the repair when you book online or mention our website.
What are your hours in Piper Glen?
We are open Monday through Saturday from 8:00 AM to 6:00 PM, and Sunday from 10:00 AM to 3:00 PM (Eastern Time). Call (980) 983-2911 or send a request online and the first available operator will call you back.
Do you serve ZIP code 28277?
Yes. We serve Piper Glen and all of Piper Glen, Charlotte, including ZIP codes 28277.
Hours & contact
Commercial Appliances is open Monday through Saturday from 8:00 AM to 6:00 PM, and Sunday from 10:00 AM to 3:00 PM (Eastern Time). We serve Piper Glen, Charlotte.
Phone: (980) 983-2911
Email: omnicommercialrefrigeration@gmail.com
Based in Charlotte, NC. We are a mobile service company — our technicians come to your business.
| Monday | 8:00 AM – 6:00 PM |
|---|---|
| Tuesday | 8:00 AM – 6:00 PM |
| Wednesday | 8:00 AM – 6:00 PM |
| Thursday | 8:00 AM – 6:00 PM |
| Friday | 8:00 AM – 6:00 PM |
| Saturday | 8:00 AM – 6:00 PM |
| Sunday | 10:00 AM – 3:00 PM |